Dash Rattle Tech Service Bulletin
Some customers may experience rattles from the dash area. The following procedures were developed to reduce noise from the dash area.Read the TSB in PDF format >>
- 2003-12-30 - Similar Articles

Intermittent Extended Or "Hard" Cranking
Synopsis:Some 2003 – 2004 model year Tacoma (V6) vehicles may experience an intermittent extended or “hard” engine cranking at startup. A revised engine wire
- 2006-04-21 - Similar Articles

REAR QUARTER PANEL PAINT CHIP PROTECTION
A new anti–chip tape has been developed to help prevent repeat occurrences of paint chipping on the rear quarter panels of Tacoma compact pick–up trucks caused by
- 2007-01-18 - Similar Articles

Wind Noise Repair Kit
A kit containing special foam sponge material has been developed. This kit, when used in conjunction with procedures outlined in the Wind Noise Service Information book (P/N 0
- 2007-01-18 - Similar Articles

TRAILER WIRE HARNESS ROUTING CHANGE
For 2001 model year Tacoma Double Cab trucks with towing hitch accessory, the interior cab wire harness routing has been changed to eliminate a bulge in the rear trim panel ca
- 2007-01-18 - Similar Articles

TUBE STEP NOISE
A Tacoma Tube Step (by Steel Horse) Field Fix Hardware Kit has been created fordealers to repair abnormal noise conditions (i.e., squeaking, rattling, and/or knocking)stemming
- 2007-01-18 - Similar Articles

FAN FLUID COUPLING REPLACEMENT FOR INCREASED TOW HITCH CAPACITY
This bulletin details the installation of a high speed fan fluid coupling on 2002 model year Tacoma 4x4 and PreRunner trucks with V6 engines to increase towing capacity to 5,0
- 2007-01-18 - Similar Articles

TRAILER WIRE HARNESS
Beginning in 2000, the accessory trailer wire harness supplier was changed and a new design was adopted which incorporated in–line fuses in the tow wire harness in addit
- 2007-01-18 - Similar Articles

RS3000 TVIP AUTOMATIC DOOR LOCK FEATURE PROGRAMMING
As a convenience feature, the RS3000 TVIP system is programmed to automatically lock all of the vehicle’s doors (for vehicles equipped with power door locks) when the ig
- 2007-01-18 - Similar Articles

TOYOTA VIP RS3000 PROGRAMMING
This bulletin describes the procedures that are used to program the two–button remote control for vehicles that are equipped with the dealer or port installed option (PI
- 2007-01-18 - Similar Articles

TONNEAU COVER FOAM WEDGE KIT
For Tacoma vehicles with under–the–rail bedliner, the Tonneau Cover Kit (P/N PT248–35032 or PT248–35033) may interfere with the tailgate bedliner. A fo
- 2007-01-18 - Similar Articles

RS3000 TVIP PROGRAMMING CHANGES FOR GBS
Starting with 1999 MY, the programming in the RS3000 ECU for the Glass Breakage Sensor (GBS) to trigger the alarm has been changed to improve the Toyota Vehicle Intrusion Prot
- 2007-01-18 - Similar Articles

TAILGATE LOCK (POP AND LOCK) TORQUE CHANGE
The torque specifications for the tailgate lock (pop and lock) assembly on 1995 through current model year Tacoma trucks have been changed as described below.View the full TSB
- 2007-01-18 - Similar Articles

FRONT DOOR WINDOW FRAME IMPROVEMENT
Tacoma vehicles that exhibit the front door glass outside the weatherstrip when in the closed position should be repaired using this bulletin. The front door window frame has
- 2007-01-18 - Similar Articles

LOOSE FENDER FLARE PADS
Some customers may experience a condition where the rubber pad between the fender flare and the body may appear loose. A field fix has been developed to resolve this condition
- 2007-01-18 - Similar Articles

DRIVER'S SIDE REAR SEAT COVER TORN
Some customers may experience tearing of the material on the driver’s side rear seat on the back cover near the tilting pivot on the right side. Replace parts as describ
- 2007-01-18 - Similar Articles

FRONT MUDGUARDS
To help prevent damage to the exterior finish of Tacoma 4x4 and PreRunner vehicles, the front mudguards have been increased in width by 25 mm.View the full TSB in PDF format &
- 2007-01-18 - Similar Articles

WATER LEAK FIELD-FIX REPAIR INSTRUCTIONS
Use the following field–fix procedures if water is present on the floor carpeting and it can be confirmed that the water is leaking into the cab from either the upper co
- 2007-01-18 - Similar Articles

VEHICLE WILL NOT UNLOCK ON FIRST REQUEST
Note:  This TSB applies to 2001 model Tacomas onlyThe power door lock system may intermittently not unlock the doors on the first activation when using a key or the RS 30
- 2007-06-05 - Similar Articles

EXHAUST MANIFOLD HEAT SHIELD RATTLE NOISE (95-00)
Some Tacoma vehicles may experience a rattle noise caused by the exhaust manifold heat shield. Two wire mesh grommets and a reinforcement patch on the underside have been adde
- 2007-06-05 - Similar Articles